UL-365型（手电筒型）紫外线探伤灯

UL-365型（手电筒型）紫外线探伤灯

UL-365紫外线探伤灯简介

适用于荧光渗透检测、荧光磁粉检测、空调制冷剂泄漏检测、发动机润滑油泄漏检测、******等多种领域。UL-365采用锂电池供电，金属高压放电紫外线灯泡和独有的高压触发器，UL-365紫外线探伤灯38cm处紫外线强度达8000uw/cm2。快速启动打开15秒后紫外灯即达到***高强度，可以开始使用，满足***渗透检测标准JB4730.5—2004，
Apply to fluorescence penetrant testing, fluorescence magnetic powder detection, air conditioning refrigerants leakage detection, engine oil leakage detection, criminal detective and so on many kinds of fields. UL-365 using lithium batteries, metal ultr***iolet light bulb high-pressure discharge and unique high pressure flip-flops, UL-365 uv lamp in 38 cm detection ultr***iolet intensity of 8000 uw/cm2. Quick start to open 15 seconds after uv lamp that is achieving the highest intensity, can begin to use, meet the national standard penetration test JB4730.5-2004,

二、基本参数Parameters:

型 号model:UL-365 Type

输出功率Output power:28W dual power

工作时间Working time:50minutes/28W (2200mAH battery)

电池Battery: 11V /2200mAH

灯头直径Thedia.Of ligh head:71mm

简身直径Thediaof body:50mm

长度Lenth:240mm

重量Weight :700g(with 2200mAHbattery)

工作温度Working temperature:0℃-50℃

颜色Color :黑色Black,silve

电池寿命Life of battery:≥500times recharge

灯泡寿命Life of lamp bulb：≥3000times recharge

紫外线强度Ultr***iolet intensity：8000μw/cm2（在38cm处）

三、产品安全功能/Product safety function:

A． 开路保护功能；启动灯，当输出发生开路异状态时，能在1秒内停止工作，进入保护状态。

B．短路保护功能；启动着灯，当输出发生短路异常时，能在1秒内停止工作，进入保护状态。

C．电池过充过放保护；充电过到指定的电压时全自动保护，放电达到指定的电压时全自动保护。

D． 电池短路保护；当电池正负极发生短路时，电池保护板将立即断电，并进入保护状态。

A． Circuit opening protection function; starting up light, when output oocur abnormal state of circuit opening,it can stop working in 1 second and get into protection state.

B． Short circuit protection function;starting up light,when output oocur abnormal state of short circuit,it can stop working in 1 second and get into prctecting state.

C． Battery recharegd protection;It is totally automatic protection in which charge/discharge be reached appointed voltaeg.

D． Battery short ciralit protection;when battery short circuit between anode and ttery protection board will cut immediately and get into prctecting state.

四、使用方法/Uing instruction:

A． 按一下开关，电筒打开、再按一下开关电筒关闭；

B．调节灯影；通过旋转灯头可调节光斑***佳；

C．充电：旋开紫外线探伤灯尾盖，取出DC电池，插上充电器充电（红色灯亮表示正在充电，红色转绿色表示已充满）。充满后，充电器指示为绿灯，充电时间约6小时。

A． Press the switch, UV-lamp open, click on the switch UV-lamp shut;

B．Adjust light shadow:swivel the UV-lamp head can adjust the focus to best condition.

C．Charge:Swivel off the UV-lamp end and take out the battery covering with protection shell,appearing Dc changer,and plug the charger(red light shows under charging,Green light shows charging full.)When full charged,the green light on.the chargetime is approximate 6 hours.

2、充、放电/Charge/discharge

A．只能用指定的充电器充电，充电环境：温度0-45°C,湿度65&plu***n;25％

B．请勿使用破损的或其他电器产品充电器进行充电；

C．充电时间4-6小时，请不要连续充电超过24小时；使用前请预先充电。

A．Only can use the appointed charger,charging environment temperature is 0-45℃,humidity is 65&plu***n;25％

B. Please don’t use damaged or other brand charger to charge.

C. Charging time is 4-6hrs,please don’t charge exceed 24hrs ease per-charge before using.

3、贮存/Storage

请在低温、干燥、通风良好的地方贮存电池；

Please store it in low temperature,dry and ventilated environment.

4、处置/Deposit

依据使用当地的***处理废旧电池。

Please deal with waste battery according to the local rule.

5、电池充电使用指导/ The battery use guidance

A. 充电电流：不能高于4000mA;

B. 充电电压：不能高于12.8V;

C. 充电环境温度：必须在0℃-40℃的温度范围内进行充电；

A. Charge current:≤4000mA

B. Charge voltage: ≤12.8V

C. Charge environmenttemperature: 0℃-40℃

6、放电环境温度/Discharge environment temperatute:

必须在-200℃-60℃的温度范围内放电使用。

Discharge environment temperature:-200℃-60℃

8、警告/Warming

A． 不要使用D型电池或其它电池代替原有电池，（为了避免***和功能影响）；

B．不要私自连接触点及不要将电池用于此紫外线探伤灯以外的其它用途；

C．请避免碰撞和摔落；

D． 长时间亮灯后，不要用手触摸玻璃，以免***手；

E． 不要自行拆开或企图自修复紫外线探伤灯，未经***的开盖或修复，不在保修之内；

F． 为了避免污染，请依据当地***处理废旧电池；

G． 不要将电池置于火中；

H． HID作为高压产品（启动瞬间电压达23KV），如果出现不正常情况，请马上将产品退回修理，千万不自修复，以免受到伤害。

I． 电池不要和金属、或导电物品混合混置，严禁短路。

A． Don’t use other battery instead of orininal one.(In order to ***oid danger and affect the function)

B．Don’t uec Ctype battery or other battery instead of original one.(In order to ***oid danger and affect the function)

C．Please ***oid impacting and falling.

D． After long time lightining,please does not UV-lamp the glass in order to ***oid scald your hands.

E． Don’t disassemble or repair UV-lamp by oneself,if open the cover or repair without authotized,it will not be under warranty.

F． In order to ***oid pollution,please deal with waste battery according to local rule.

G． Don’t thr ow the battery into fire.

H． HID is a high voltage product.(starying temporary voltage approach 23KV)If it appears some abnor mal conditi***,please return to us for repair right order to ***oid harm oneself,don’t repait itperson ally.

I． Iatis forbidden to short the circuit,piease prt the battery with metal or con drctor together.

七、UL-365紫外线探伤灯标准配置
主机 1台

电池 1个
充电器 1只

车载充电器 1只

擦镜布 1块
说明书 1份
铝合金箱 1只
装箱单 1份

产品保修卡 1份