PAHS高环保系列漆PAHS high environmental protection series of paint
PAHS高环保油漆系列符合ROHS、PAHS一类、PAHS二类、REACH、TUV等环保检测要求，在ABS、PVC、PC、五金、铝合金、PPS、家电、汽车内外饰件、尼龙玻纤维、有机玻璃等塑料上附着力优异,适合烤漆、低温喷涂，耐酒精和***擦拭，该环保系列漆通过PAHS检测，16种PAHS总和小于10mg/kg。在环保要求高的电子、电器、家电、天文望远镜、***产品上广泛应用。
PAHS high environmental protection paint series in line with ROHS, PAHS category, PAHS category, REACH, TUV and other environmental testing requirements, in ABS, PVC, PC, ha***are, aluminum, PPS, home appliances, automotive interior and exterior parts, nylon glass, organic Glass and other plastic on the adhesion of excellent, suitable for paint, low temperature spray, alcohol and gasoline wipe, the environmental protection series of paint through the PAHS test, 18 PAHS sum less than 10mg / kg. In the environmental requirements of high electronics, electrical appliances, home appliances, telescopes, military products widely used.
一、适用范围：
适用于ABS、PVC、PC、五金、铝合金、PPS、家电、汽车内外饰件、尼龙玻纤维、望远镜、有机玻璃等表面喷涂。
Scope of application：
Applicable to ABS, PVC, PC, ha***are, aluminum, PPS, home appliances, automotive interior and exterior trim, nylon glass fiber, telescope, plexiglass and other surface spray.
二、理化指标:
1、厚度: 8μm-10μm
2、硬度: ≥4H
3、附着力: 0级
4、耐酒精(耐溶剂)性:涂油表面无*** 用浓度为95%的酒精的毛巾，用8KG的力在涂层上擦拭
300次后，涂油无***。
5、耐热性:涂油无明显变色、气泡、脱落、裂纹等现象 经120℃烘烤2h
6、耐沸水性:涂油无变色、气泡、脱落、裂纹等现象 经100℃的水中煮沸4h
7、防腐蚀性:除切口允许少量锈迹外,其它表面应无任何腐蚀生锈现象 在盐雾试验箱内用NSS方
法连续喷雾20小时后，观察
Physical and chemical indicators:
1, thickness: 8μm-10μm
2, hardness: ≥ 4H
3, adhesion: 0 level
4, alcohol (solvent): no damage to the oil surface with 95% alcohol concentration of the towel, with 8KG force in the coating on the wipe 300 times, no oil damage.
5, heat resistance: oil no significant color, bubbles, loss, cracking and other phenomena by 120 ℃ baking 2h
6, resistance to boiling water: oil without discoloration, bubbles, shedding, cracks and other phenomena by boiling water 100 ℃ 4h
7, anti-corrosion: In addition to allowing a ***all amount of rust stains, the other surface should not h***e any corrosion rust phenomenon in the salt spray test chamber with NSS continuous spray 20 hours, observed
三、使用方法:
根据各种加工工艺的要求，可采用多种不同形式的涂油方法（如辊涂、刷涂、喷涂、浸涂等）。
Usage method:
According to the requirements of various processing technology, can use a variety of different forms of spraying methods (such as roller coating, brush coating, spraying, dip coating, etc.).
四、注意事项：
1、初次使用，先在局部小面积试用，效果满意后，再大面积使用。
2、避开雨天或高湿天气施工，禁止带水操作。
3、除油、除锈、除杂应彻底，确保工件表面洁净干燥。
4、勿食勿饮，施工时保持通风良好。本品***，避开火源施工。
5、此环保系列油漆如需达到高标准PAHS环保要求，必须选用环保专用溶剂，同时在喷涂前需用环保专用溶剂对喷涂工件进行彻底清洁处理。
Matters needing attention：
1, the initial use, first in a ***all area of local trial, the results are satisfactory, and then a large area.
2, to ***oid rain or high humidity c***truction, with water operation prohibited.
3, degreasing, rust, impurity removal should be thorough, to ensure clean and dry surface of the workpiece.
4, do not eat do not drink, to maintain good ventilation during c***truction. This product is flammable, to ***oid the fire source c***truction.
5，This environmentally friendly series of paint in order to achieve high standa*** of environmental protection PAHS requirements, must use environmentally friendly solvents, and spraying before the need for environmental protection solvent for the workpiece thoroughly cleaned.
以资料仅参考，不具备***依据及***责任
In data for reference only and do not h***e a legal basis and guarantee resp***ibility